|Year : 2021 | Volume
| Issue : 1 | Page : 22-26
Characteristics of fatty acid composition and minor constituents of red palm olein and palm kernel oil combination
Marline Nainggolan1, Ahmad Gazali Sofwan Sinaga2
1 Department of Pharmaceutical Biology, Universitas Sumatera Utara, Medan, Indonesia
2 Research Division, Indonesian Oil Palm Research Institute, Medan, Indonesia
|Date of Submission||10-Jul-2020|
|Date of Decision||21-Jul-2020|
|Date of Acceptance||21-Sep-2020|
|Date of Web Publication||09-Jan-2021|
Dr. Marline Nainggolan
Tri Dharma Street, No. 5, Gate 4th, University of North Sumatera,
Source of Support: None, Conflict of Interest: None
Red palm olein (RPOl) is one of the derivatives of palm oil. It contains a high composition of unsaturated fatty acids such as oleic and linoleic, whereas palm kernel oil (PKO) contains more saturated fatty acids of lauric acid. RPOl provides high nutrient contents such as squalene, Vitamin E, and carotene, whereas PKO that is rich in lauric acid can fight Gram-positive microorganisms. This research aims to study the chemical characteristics of RPOl, PKO, and the combination. A combination of RPOl with four different concentrations of PKO (20%, 50%, 80%, and 100%) was analyzed to obtain the composition of fatty acids, squalene content, Vitamin E levels, total carotene, and saponification numbers. RPOL contains high levels of squalene, Vitamin E, and total carotene, followed by RPOl and PKO combination of oil, with a higher percentage of RPOl in its composition. The increase of the PKO level added to the combination will decrease the saponification number and increasing the acid number. Therefore, it can be concluded that RPOl could be the source of squalene, Vitamin E, carotenoids, and oleic acid, whereas PKO is the largest source of lauric acid.
Keywords: Carotenoids, fatty acid, palm kernel oil, red palm olein, squalene, Vitamin E
|How to cite this article:|
Nainggolan M, Sinaga AG. Characteristics of fatty acid composition and minor constituents of red palm olein and palm kernel oil combination. J Adv Pharm Technol Res 2021;12:22-6
|How to cite this URL:|
Nainggolan M, Sinaga AG. Characteristics of fatty acid composition and minor constituents of red palm olein and palm kernel oil combination. J Adv Pharm Technol Res [serial online] 2021 [cited 2021 Jun 22];12:22-6. Available from: https://www.japtr.org/text.asp?2021/12/1/22/306567
| Introduction|| |
The oil palm produces crude palm oil (CPO) and palm kernel oil (PKO). While CPO is developed from the fruit, the modified refining process develops the red palm oil (RPO). The palm oil refinery process consists of the degumming or the separation of gum, deacidification (neutralization), bleaching, and deodorization. During the bleaching process, the minor components of palm oil, especially carotene, are mostly discarded as waste for the purpose of obtaining clear-colored cooking oil. By modifying the purification with, CPO is then processed to produce RPO. RPO is the palm oil derivatives that are obtained without going through a bleaching process with the aim of maintaining the carotenoid content. RPO is rich in unsaturated fatty acids such as oleic and linoleic. PKO, on the other side, is rich in saturated fatty acids, namely lauric acid.
RPO contains carotenoids and also other minor components, such as Vitamin E, and squalene which are antioxidants in palm oil.,, Vitamin E, squalene, and carotene are natural antioxidants widely used in topical formulations. These antioxidants play a significant role in protecting biomembranes against peroxidation, protecting the skin from sunlight while maintaining skin moisture, and increasing body endurance. For the reasons above, a research on the characterization of the chemical compounds of RPO and PKO combination was conducted.
| Materials and Methods|| |
The materials used in this research are RPO and PKO. Other materials are sodium hydroxide (NaOH), boron trifluoride (BF3), methanol, hexane, sodium chloride (NaCl), hydrochloric acid (HCl), potassium hydroxide (KOH), ethanol, Vitamin C, and phenolphthalein.
Samples of RPO and PKO are combined in the following ratios of 100:0, 80:20, 50:50, 20:80, and 0:100. Furthermore, the five samples were characterized by the fatty acid composition, squalene, Vitamin E, and total carotenoids. In addition, the combinations of oil samples were tested for saponification numbers.
Determination of fatty acid composition
An accurately weighed 0.025 g of sample in a test tube was combined with 1.5 ml of 0.5 N methanolic NaOH. The test tube was tightly closed and vortexed for 1–2 min. The samples were then heated in 100°C water bath for 5 min and brought to room temperature. About 2 ml of BF3 methanol was added into and it was vortexed for 1–2 min. The test tube was then closed tightly and reheated at 100°C for 30 min. Additional 5 ml of saturated NaCl was added into the test tube to be closed and vortexed again. Vortex was conducted until two layers were formed. The top layer was moved into the vial to be later analyzed using the gas chromatography–mass spectrometry (GCMS) tool.
Determination of squalene composition
An accurately weighed 0.5 g of sample in a test tube was combined with 5 ml of ethanol–Vitamin C 0.1% and was homogenized with a vortex. The samples were heated at 80°C for 15 min. About 3 ml of 50% KOH was added into and brought to room temperature. It was homogenized with a vortex and reheated at 80°C for 30 min. About 10 ml of 40% ethanol was added into and brought to room temperature and then homogenized again. Ten milliliters of hexane was taken using a 10 ml volumetric pipette and added to the sample. They were homogenized again with a vortex for 1 min. The sample was then analyzed using the GCMS tool.
Determination of Vitamin E levels
A sample weighed 2 g was brought into a 10 ml volumetric flask. Hexane was added and adjusted to reach 10 ml mark level and then homogenized. About 2 ml of sample in a 10 ml volumetric flask was combined with methanol and adjusted to reach 10 ml mark level and then homogenized again. Then, the sample was poured into a centrifuge bottle (centrifuge for 30 min at 3000 rpm). The sample was then analyzed using ultra-performance liquid chromatography.
Determination of total carotenoids
A sample weighed 0.04 g was brought into a 10 ml volumetric flask. Hexane was added and adjusted to reach 10 ml mark level. The sample was then analyzed using a spectrophotometer. Absorbance at a wavelength of 446 nm was read.
Determination of the saponification value
A sample weighed 2 g was brought into a 500 ml Erlenmeyer flask. KOH-alcoholic solution 0.5 N was added about 25 ml. Then, the Erlenmeyer was connected to an air conditioner (upright cooler) and boiled over a water bath for half an hour. The sample was then titrated and brought to room temperature with HCl 0.5 N and phenolphthalein as indicators.
| Results and Discussion|| |
Determination of fatty acid composition
RPO is mainly composed of oleic acid and linoleic acid, the unsaturated fatty acids. Meanwhile, PKO contains more lauric acid which is a saturated fatty acid., As a result, a combination of RPO and PKO produces new oil types containing more diverse composition of unsaturated and saturated fatty acid composition. The fatty acid composition of red palm olein, palm kernel oil, and oil combination is shown in [Table 1]. Based on analysis results, RPO shows no caproic fatty acids in the content. On the other hand, RPO and PKO combinations show richer composition and do contain caproic fatty acids. Lauric acid (C: 12-0) and myristic acid (C: 14-0) are found to be greatest in PKO, 45.61% and 16.25%, respectively. The level of content is then followed by the RPO-PKO combined oil that is greater than the content of RPO. The percentage of palmitic acid (C: 16-1), oleic acid (C: 18-1), and linoleic acid (C: 18-2) is found the greatest in RPO, with a value of 42.23%, 41.58%, and 10.71%, respectively.
|Table 1: The composition of fatty acid in red palm olein, palm kernel oil, and oil combination|
Click here to view
Fatty acids with 12–14 carbon chains provide a good function for foaming, while fatty acids with 16–18 carbon chains are good for hardness and detergent power. Fatty acids with <12 carbon chains can cause skin irritation, while fatty acids with more than 18 carbon chains constructed soap that has a very low solubility. Saturated fatty acids like lauric acid are the most active saturated fatty acids against Gram-positive microorganisms., In the body, lauric acid will be converted into monolaurin which has antibacterial ability, and the modification of lauric acid can protect the skin from bacterial infections. The higher lauric acid in a fatty acid composition will affect the antibacterial activity of liquid soap. Each type of fatty acid will have different properties in soap. The properties of the resulted soap are determined by the quality and composition of the fatty acids used.
The saponification value is determined by the number of milligrams of KOH required to develop a reaction with 1 g of fat. Oil, which is composed of short carbon chain fatty acids, shows a high saponification value when compared to oil which is composed of long carbon chain fatty acids. The saponification values of RPO, PKO, and the combination are shown in [Figure 1].
|Figure 1: Saponification value of red palm olein, palm kernel oil, and oil combinations|
Click here to view
Based on the results, RPO has relatively smaller saponification rates compared to PKO and blended oil. Hence, the red palm olein (RPOl) is better used as a soap with a gentle form (liquid), whereas PKO is better used as a soap with a hard form (solid). However, the mixture of both shows better saponification value so that it will produce liquid soap with a good cleaning action.
Squalene is a triterpene group compound found in the skin lipid layer of about 13%. The squalene content in RPO, PKO, and the combination is shown in [Figure 2].
|Figure 2: Saponification value of red palm olein, palm kernel oil, and the combination|
Click here to view
The data showed that the level of squalene in RPO decreases along with the addition of PKO. RPOL showed a relatively higher squalene content compared to PKO. Squalene serves as a reducer of singlet oxygen radicals, which protects the human skin surface from lipid peroxidation due to ultraviolet (UV) exposure and other oxidative damage. It is not very susceptible to peroxidation.
Vitamin E is an antioxidant that is mostly soluble in body fat; thus, it is important in skin protection. The content of Vitamin E in RPO, PKO, and the combination is shown in [Figure 3].
|Figure 3: Vitamin E concentration of red palm olein, palm kernel oil, and the combination|
Click here to view
Based on the data, it can be seen that the content of RPOL has a very high Vitamin E content compared to PKO. The use of Vitamin E on the skin aims to protect skin tissue against oxidative damage caused by UV irradiation in vivo. In previous studies, the administration of Vitamin E significantly decreased the epidermal lipid hydroperoxides formed after UV irradiation. In addition, Vitamin E has been shown to be efficacious in the treatment of melasma by depigmentation mechanism by disruption of lipid peroxidation in melanocyte membranes, increasing intracellular glutathione levels, and inhibiting tyrosinase.
Carotenoids are one of the antioxidants that have the potential to inhibit singlet oxygen. Carotenoids can also be found in skin tissue in the form of α-, γ-, β-carotene, lycopene, lutein, zeaxanthin, and their isomers. The total carotenoids in RPO, PKO, and the combination are shown in [Figure 4].
|Figure 4: Carotenoids concentration of red palm olein, palm kernel oil, and the combination|
Click here to view
Based on the data, it can be seen that RPO has higher total carotenoid content compared to PKO. High carotenoid content causes red color in RPO, compared to PKO which has a low carotenoid content causing yellow color. The potential use of carotenoids as antioxidants, especially in the skin as an inhibiting agent of UVA and UVB radiation. Carotenoids have a function as antioxidants that can inhibit UVA and UVB radiation on the skin.
| Conclusion|| |
It is concluded that the combination of RPO and PKO produces oil with more diverse characteristics. The high level of RPO in the mixture content will produce higher levels of squalene, Vitamin E, and total carotene. The combination oil of RPOL with 20% PKO produced a balanced composition of oleic acid and lauric acid. These combinations also a high concentration of carotenoid, Vitamin E, and squalene, which means great potential for health supplement. This oil combination contains high levels of carotenoids, vitamin E, and squalene, so it has the potential to be used as a source of natural medicine.
Financial support and sponsorship
Conflicts of interest
There are no conflicts of interest.
| References|| |
Ketaren S. Pengantar Teknologi Minyak Dan Lemak Pangan. 1st
ed. Jakarta: Universitas Indonesia Piublishers; 1986. p. 250.
Sinaga AG, Siahaan D, Sinaga KR. Potensi Minyak Sawit Merah Dan Karotenoid Sebagai Suplemen Antioksidan Dalam Pengujian Toleransi Glukosa Pada Tikus Putih (Preliminary Study). Medan, Indonesia. TM Conference Series 01; 2018. p. 251-6.
Ulfah M, Ruswanto A, Ngatirah N. Karakteristik minyak campuran dari red palm oil dengan palm kernel olein. Agritech 2016;36;145-51.
Gunstone FD. Vegetables Oils In Food Technology: Composition, Properties and Uses. New York: Blackwell Publishing Ltd.,; 2002. p. 76.
Njoku PC, Egbukole MO, Enenebeaku CK. Physio-chemical characteristics and dietary metal levels of oil from elaeis guineensis species. Pak J Nutr 2010;9;137-40.
Sinaga AG, Siahaan D. Antioxidant activity of bioactive constituents from crude palm oil and palm methyl ester. Int J Oil Palm 2019;2;46-52.
Weber SU, Lodge JK, Saliou C, Packer L. Antioxidants. In: Barel AO, Paye M, Maibach HI, editors. Handbook of Cosmetic Science and Technology. New York: Marcel Dekker Inc.,; 2001. p. 299-310
AOCS. Fatty acid composition by GLC. In: Firestone D, editor. Official Methods and Recommended Practice of the AOCS. 5th
ed. Illinois: American Oil Chemists' Society Champaign; 1997. p. 1-62, 1-4.
O'Neil HJ, Gershbein LJ. Determination of cholesterol and squalene by gas chromatography. Anal Chem 1961;33;182-5.
AOCS. Determination of Tocopherol and Tocotrienol in Vegetable oils and Fats by HPLC. In: Firestone D, editor. Official methods and recommended practice of the AOCS. 5th
Ed. Illinois: American Oil Chemists' Society Champaign; 1997. AOCS Official Method Ce 8-89. p. 1-5
MPOB. Method of test for palm oil and palm oil products: Determination of Carotene Content. In: Kuntom A, Lin SW, Ai TY, Idris NA, Yusof M, Sue TT, et al. editors. MPOB Test Method: A Compendium of Test on Palm Oil Products, Palm Kernel Products, Fatty Acids, Food Related Products and Others. Kuala Lumpur: Malaysian Palm Oil Board; 2005. p. 2.6, 194-7.
AOCS. Saponification value. In: Firestone D, editor. Official Methods and Recommended Practice of the AOCS. 5th
ed. Illinois: American Oil Chemists' Society Champaign; AOCS Official Method Da 1997. p. 16-48, 1.
Dauqan E, Pagesimah AS, Aminah A, Zalifah MK. Effect of different vegetable oils (red palm olein, palm olein, corn oil and coconut oil) on lipid profile in rat. Food Nutr Sci 2011;2:253-8.
Kaneko D, Sakamoto K. Skin cleansing liquids. In: Barel AO, Paye M, Maibach HI. Handbook of Cosmetic Science and Technology. New York: Marcel Dekker, Inc.,; 2001. p. 299-310
Kabara JJ, Swieczkowski DM, Conley AJ, Truant JP. Fatty acids and derivatives as antimicrobial agents. Antimicrob Agents Chemother 1972;2:23-8.
Conley AJ, Kabara JJ. Antimicrobial action of esters of polyhydric alcohols. Antimicrob Agents Chemother 1973;4:501-6.
Sulastri E, Mappriratu, Sari K. Uji aktivitas antibakteri krim asam laurat terhadap Staphylococcus aureus
ATCC 25923 Dan Pseudomonas aeruginosa
ATCC 27853. Galenika J Pharm 2016;2;59-67.
Mathur A. Extraction and studies on saponification values of some non-edible seed oils from arid zone of Rajasthan. Int J Curr Eng Sci Res 2016;3;6-8.
Passi S, De Pità O, Puddu P, Littarru GP. Lipophilic antioxidants in human sebum and aging. Free Radic Res 2002;36:471-7.
Huang ZR, Lin YK, Fang JY. Biological and pharmacological activities of squalene and related compounds: Potential uses in cosmetic dermatology. Molecules 2009;14:540-54.
Lopez-Torres M, Thiele JJ, Shindo Y, Han D, Packer L. Topical application of alpha-tocopherol modulates the antioxidant network and diminishes ultraviolet-induced oxidative damage in murine skin. Br J Dermatol 1998;138:207-15.
Keen MA, Hassan I. Vitamin E in dermatology. Indian Dermatol Online J 2016;7:311-5.
] [Full text]
Khoo HE, Prasad KN, Kong KW, Jiang Y, Ismail A. Carotenoids and their isomers: Color pigments in fruits and vegetables. Molecules 2011;16:1710-38.
Darvin ME, Fluhr JW, Meinke MC, Zastrow L, Sterry W, Lademann J. Topical beta-carotene protects against infra-red-light–induced free radicals. Exp Dermatol 2011;20;125-9.
[Figure 1], [Figure 2], [Figure 3], [Figure 4]